Send a Message

Contact Us

Company Address

Zhengzhou, China.

“PERFORMANCE OF CONCRETE BY USING GLASS POWDER”

use of glass powder in concrete” by ACI committee 234(7).All the samples were prepared using design mix. M35 grade of concrete was used for the present investigation. Mix design was done based on I.S 10262-1982. The Table 5 shows mix proportion of concrete (Kg) Table 5: Mix Proportioning

Effect of Using Glass Powder in Concrete

C. Mix design: The concrete mix without glass powder was proportioned as per Indian Standard Specifications IS: 10262-1982. Mix design was done for M20 grade of concrete. The mixture was prepared with water to cement ratio of 0.5. The mix proportion of materials is 1:2.35:4.47 as per IS 10262-2009. Then natural fine aggregate was used.

Utilisation of Waste Glass Powder in Concrete A Literature

In order to provide a sustainable solution to glass storage, a potential and incentive way would be to reuse this type of glass in concrete [Idir R, 2009].This paper present literature review on replacement of cement by waste glass powder which includes current and future trends of research on the use of crushed glass powder in Portland cement

Effect of Glass Powder on Concrete Sustainability

The use of crushed glass as GP in concrete is relatively recent. The high alkali content of the glass makes easier the development of alkali-silica reaction that can generate damaging stresses and cracking in concrete, when glass is used as aggregate. Yet when it is ground into fine powder and used as partial replacement of cement, it develops

Use of waste glass in concrete: A review

Use of glass powder and aggregates as partial replacement in concrete. Use of Waste Glass Powder as a Replacement in Concrete Vijay kumar et al. (2013) [19] examined that worldwide concrete industry contributes around 7% of ozone depletion gases to the earth’s atmosphere. So in this research finely glass powder

Performance of Using Waste Glass Powder In Concrete As

2.1 Using Waste Glass Powder in Concrete Mix Basically waste glass powders are made from the waste glass material that cannot be reused due to the high cost of manufacturing. Therefore the manufacture will disposed in the waste landfill. Due to environmental problem, researcher tries to use the waste glass in to concrete, to create a new

Experimental Study on Concrete Using Cement With Glass

concrete; from the results obtained, it is found that glass powder can be used as cement replacement material up to particle size less than 75μm to prevent alkali silica reaction. Keywords: Experimental Study, Concrete, Using Cement, Glass Powder I INTRODUCTION Concrete is a blend of cement, sand, coarse aggregate and water.

The effects of waste glass powder usage on polymer

Oct 01, 2013 The effects of waste glass powder usage on polymer concrete properties are investigated. • Effects of resin amount in workability are examined. • Waste glass powder increased the workability of polymer concrete. • Waste glass powder increased the

Waste glass powder as partial replacement of cement for

Jun 01, 2017 The glass powder replacement in cement was varied (0–25%). Mix proportion of concrete is shown in Table 6. Firstly, stone chips and sand were dry mixed for a minute. Appropriate quantity of glass powder was blended with cement in a separate container and then incorporated into the aggregate matrix (mixed earlier).

Ground-Glass Pozzolan for Use in Concrete

Glass Pozzolan for Use in Concrete.” The new specification was published earlier this year, after 3-1/2 years of balloting by the committee. This article provides much of the background information and industry context that accompanied the balloting. Motivation Glass production is a major source of greenhouse gases.

Ground-Glass Pozzolan for Use in Concrete

Glass Pozzolan for Use in Concrete.” The new specification was published earlier this year, after 3-1/2 years of balloting by the committee. This article provides much of the background information and industry context that accompanied the balloting. Motivation Glass production is a major source of greenhouse gases.

Study of Concrete Involving Use of Waste Glass as Partial

using waste glass powder as partial replacement of fine aggregates up to 30% by weight for particle size of range 0-1.18mm. Keywords: Compressive strength, Durability, split tensile strength, Waste Glass Concrete, Workability. I. INTRODUCTION In order to make concrete industry sustainable, the use of waste materials in place of natural resources

(PDF) EXPERIMENTAL STUDY ON USE OF WASTE GLASS POWDER

Glass powder concrete increases the compressive strength, tensile strength and flexural strength effectively. The optimum usage percentage of glass powder is 10%.2. split tensile test on cubes ISSN: 2277-9655 [Lalitha * et al., 6(10): October, 2017] Impact Factor: 4.116 IC™ Value: 3.00 CODEN: IJESS7 [30] Fig.3.graph showing tensile test

Glass Powder Refractory Application African Pegmatite

Application of Glass Powder in Concrete. Concrete is made by combining cement, aggregate, and water with any additives necessary to achieve the necessary properties, like colourants or plasticisers. Glass powder can be used as a pozzolan, which is a type of siliceous material that reacts in water and calcium hydroxide. The addition of pozzolans

Experimental Study On Replacement Of Cement By Glass

glass powder is economically cheap as well as a superior concrete can be made. 1.0 INTRODUCTION . The quantity of waste glass has slowly increased over the years due to the growing need and usage of glass products, this gives way for large quantity of glass waste. Most of

[PDF] The Use of Sheet Glass Powder as Fine Aggregate

Sheet glass powder (SGP) used in concrete making leads to greener environment. In shops, near by Chidamba- ram many sheet glass cuttings go to waste, which are not recycled at present and usually delivered to landfills for disposal. Using SGP in concrete is an interesting possibility for economy on waste disposal sites and conservation of natural re- sources.

Effect of glass powder on the compression strength and the

To overcome this confusion the present research aimed to study the effects of glass powder on the properties of concrete by series of test for two constant quantities of cement, 350 and 400 kg per cubic meter. To reach the target of this research, two campaigns were done. In the first campaign the glass powder is gradually increased from trial

partial replacement of fine aggregate by glass powder in

Apr 05, 2015 The partial replacement of glass powder as fine aggregate Makes the concrete strengthen. Thus our project states that concrete can be strengthen by glass powder replacement,which makes the waste in to useful, so the waste materials made in to use.

Study of Waste Glass Powder as Pozzolanic Material in

demonstrates that that waste glass powder can be utilized as concrete substitution material up to molecule size littler than 75μm to maintain a strategic distance from salt silica response. Inferred that supplanting of bond with glass powder by 20%, 30% and 40% upgrade the compressive quality by 19.6%, 25.3% and 33.7% correspondingly.

Waste Glass Powder as Cement Replacement in Concrete

The pozzolanic reactivity of waste glass powder was experimentally studied at cement replacement levels of 0, 15, 30, 45 and 60% by weight. Results revealed that the concrete compressive strength was not decreased by the cement substi-tution after 28 days because of the pozzolanic reaction between glass powders and cement hydration products, if the replacement is below 30%.

Utilizing Waste Recycled Glass as Sand/Cement Replacement

Dec 12, 2009 The potential use of waste recycled glass in concrete as recycled glass sand (RGS) and pozzolanic glass powder (PGP) was examined in this study. No major difference was found in compressive strength of concrete with the presence of RGS as sand replacement.

Effect of Partial Replacement of Cement by Mixture of

concrete was prepared without mixture of glass powder and silica fume to compare it with the various samples containing different percentages of mixture of glass powder and silica fume as a partial replacement of cement in concrete. Results discovered that the usage of mixture of glass powder and silica fume in concrete as a partial replacement

Old glass may find use in new, better concrete

Jun 11, 2019 Additionally, because sand has to be mined, washed and graded, it was determined that use of the ground glass resulted in lower concrete production costs.

The Use of Sheet Glass Powder as Fine Aggregate

The Use of Sheet Glass Powder as Fine Aggregate Replacement in Concrete The Open Civil Engineering Journal, 2010, 4: 65-71 M. Mageswari, Dr. B. Vidivelli Research Scholar, Structural Engineering, Annamalai University, Annamalai nagar, 600 002, Tamilnadu, India.

[PDF] Effect of Using Glass Powder in Concrete Semantic

Waste glass is one materials when ground to a very fine powder shows pozzolanic properties which can be used as a partial replacement for cement in concrete. In this paper, an attempt has been made to find out the strength of concrete containing waste glass powder as a partial replacement of cement for concrete.

What to Expect When Mixing Concrete With Glass Concrete

Jul 09, 2011 The glass powder, which is recommended for projects where you would use white cement, also prevents efflorescence and makes the concrete stronger. The CWC report also notes that a set retarder can be added to slow the cement’s curing time.

Influence of Glass Powder on the Properties Of Concrete

Concrete with replacement of cement by waste glass powder such as 5%, 10%, 15 % and 20 % were produced and properties of this concrete has been compared with concrete of control mix with no replacement. Cube specimens of 24 numbers were cast, cured

[PDF] The Use of Sheet Glass Powder as Fine Aggregate

Sheet glass powder (SGP) used in concrete making leads to greener environment. In shops, near by Chidamba- ram many sheet glass cuttings go to waste, which are not recycled at present and usually delivered to landfills for disposal. Using SGP in concrete is an interesting possibility for economy on waste disposal sites and conservation of natural re- sources.

GFRC Glass Fiber Reinforced Concrete The Concrete Network

Aug 21, 2020 The material used to make boats or other products, although called fiberglass, is really glass fiber reinforced plastic-glass fibers in a polymer matrix. If, instead of the polymer, we use portland cement and sand, the resulting material is glass fiber reinforced concrete--GFRC or sometimes GRC (the Brits call it glassfibre reinforced concrete).

Study of Waste Glass Powder as Pozzolanic Material in

demonstrates that that waste glass powder can be utilized as concrete substitution material up to molecule size littler than 75μm to maintain a strategic distance from salt silica response. Inferred that supplanting of bond with glass powder by 20%, 30% and 40% upgrade the compressive quality by 19.6%, 25.3% and 33.7% correspondingly.

Old glass may find use in new, better concrete

Jun 11, 2019 Additionally, because sand has to be mined, washed and graded, it was determined that use of the ground glass resulted in lower concrete production costs.

Waste Glass Powder as Cement Replacement in Concrete

The pozzolanic reactivity of waste glass powder was experimentally studied at cement replacement levels of 0, 15, 30, 45 and 60% by weight. Results revealed that the concrete compressive strength was not decreased by the cement substi-tution after 28 days because of the pozzolanic reaction between glass powders and cement hydration products, if the replacement is below 30%.

Concrete Materials Research at Columbia University

The use of crushed waste glass as aggregate in concrete is problematic because of the chemical reaction between the alkali in the cement and the silica in the glass. This alkali-silica reaction (ASR) creates a gel, which swells in the presence of moisture, causing cracks and unacceptable damage of the concrete. It can also occur in regular

Vitro Minerals Recycled Glass Fillers and Extenders

Working with the Concrete and Glass Industry, Vitro Minerals has just established a new ASTM Standard, C 1866, for glass powders as pozzolans for concrete. While the glass powder is not cementitious by itself, when mixed with cement powder and water the glass reacts to reduce efflorescence inducing lime by chemically converting it to CSH, which

Effect of Partial Replacement of Cement by Mixture of

concrete was prepared without mixture of glass powder and silica fume to compare it with the various samples containing different percentages of mixture of glass powder and silica fume as a partial replacement of cement in concrete. Results discovered that the usage of mixture of glass powder and silica fume in concrete as a partial replacement

Utilizing Waste Recycled Glass as Sand/Cement Replacement

Dec 12, 2009 The potential use of waste recycled glass in concrete as recycled glass sand (RGS) and pozzolanic glass powder (PGP) was examined in this study. No major difference was found in compressive strength of concrete with the presence of RGS as sand replacement.

The Use of Sheet Glass Powder as Fine Aggregate

The Use of Sheet Glass Powder as Fine Aggregate Replacement in Concrete The Open Civil Engineering Journal, 2010, 4: 65-71 M. Mageswari, Dr. B. Vidivelli Research Scholar, Structural Engineering, Annamalai University, Annamalai nagar, 600 002, Tamilnadu, India. Electronic publication date 9/8/2010 [DOI: 10.2174/18741495010040100065]

What Are The Pros And Cons Of Fiber Mesh Concrete

Concrete needs to be sturdy and last a long time. One way to help concrete be its best is to use fiber mesh concrete. Fiber mesh concrete involves adding fibers to a ready-made concrete solution. The fibers will help reinforce the solution. Different fibers such as glass, steel, and synthetic or natural fibers are mixed in to form the mesh.